Date post: | 28-Jan-2021 |
Category: | Documents |
Upload: | others |
View: | 31 times |
Download: | 4 times |
Download Report this document
Share this document with a friend
4
1 3 09-15 SUBJECT DATE SPN 3251 (ACM)(EPA10) March 2015 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 3251/FMI 16 - EPA10 Updated diagnostic with new DOC cleaning option. 3 09-15 All information subject to change without notice. 3 3 09-15 Copyright © 2015 DETROIT DIESEL CORPORATION
Transcript
1 3 09-15
SUBJECT DATE
SPN 3251 (ACM)(EPA10) March 2015
Additions, Revisions, or Updates
Publication Number / Title Platform Section Title Change
DDC-SVC-MAN-0084 DD PlatformSPN 3251/FMI 16 -
EPA10Updated diagnostic with new DOC cleaning option.
3 09-15
All information subject to change without notice. 3309-15 Copyright © 2015 DETROIT DIESEL CORPORATION
2 SPN 3251/FMI 16 - EPA10
Diesel Particulate Filter Pressure Out of Range High
Table 1.SPN 3251/FMI 16
Description This Fault Code Sets when the Diesel OxidationsCatalyst (DOC)Inlet Pressure is 28 kPa (4.2 psi) Greater Than theDiesel ParticulateFilter (DPF) Outlet Pressure for More Than 10Seconds
Monitored Parameter DOC Inlet Pressure Sensor and DPF OutletPressure Sensor
Typical Enabling Conditions Always On
Monitor Sequence None
Execution Frequency Continuous When Enabling Conditions Met
Typical Duration 2 Seconds
Dash Lamps MIL, CEL, SEL
Engine Reaction Derate 25%
See AlsoSPN 3055 FMI 15 Below Minimum with Maximum Command ... · SPN 157 FMI 3 (FRP), SPN157 FMI 4, SPN 157 FMI 20, and SPN 157 FMI 21 (FRP), and SPN 633 FMI 3, SPN 633FMI 4, and SPN 633 - [PDF Document]TOURING - CH Bus Sales · PDF file4|TS 45 Rev. 00 / 14.05.14 FAUT CODES EnginE (Cummins) SPN FMI TEMSA DTC J1939 SPN/FMI Description Cummins Fault Code Cummins Description 629 12 - [PDF Document]SPN 3251/FMI 0, 1, and 16 - Freightliner Trucks · 2014-04-23 · SPN 3251/FMI 0, 1, and 16 SPN 3251/FMI 0, 1, and 16 Keywords: The diagnostics have been corrected and are all new. - [PDF Document]INDMAR diagnostic manual v.3 - BAKES 168 FMI 17 Battery Voltage (VBat) Low 182 SPN 515 FMI 0 RPM Above Spark Rev Limit Level 226 SPN 515 FMI 16 RPM Above Fuel Rev Limit Level 224 SPN - [PDF Document]Verification Run Engine Between 1200 to 1800 rpm With a LoadLess Than 10%
Check as follows:1. Connect DiagnosticLink ®.2. Turn theignition ON (key ON, engine OFF).3. Check for other fault codes.Are fault codes SPN 3609/FMI 3 or FMI 4 present?
a. Yes; diagnose the other fault codes first.b. No; Go to step4.
4. Using DiagnosticLink, go to Service Routines > SCR and DPFvoltages.5. Monitor the DOC inlet pressure sensor voltage, pin 87.Is the voltage between 0.44 and 0.56 volts?
a. Yes; Go to step 6.b. No; replace the DOC inlet pressuresensor. Refer to section "Removal of the EPA10 Diesel OxidationCatalyst
Inlet Pressure Sensor". Verify repair.6. Monitor the DPF outletpressure sensor voltage, pin 72. Is the voltage between 0.44 and0.56 volts?
a. Yes; Go to step 7.b. No; replace the DPF outlet pressuresensor. Refer to section "Removal of the EPA10 Diesel ParticulateFilter
Outlet Pressure Sensor". Verify repair.7. Perform the Lowtemperature ATD routine. Refer to section "EPA10 PerformPerformance Check - Low Temperature
ATD".8. Monitor the DOC inlet temperature, DOC outlettemperature and the DPF outlet temperature readings. Does theDOC
outlet temperature sensor reading follow the DOC inlettemperature sensor reading?a. Yes; replace the DPF due to arestriction. Refer to section "Removal of the EPA10 DieselParticulate Filter".
Verify repair.b. No; Go to step 9.
WARNING: PERSONAL INJURY
To avoid injury before starting and running the engine, ensurethe vehicle is parked on a levelsurface, parking brake is set, andthe wheels are blocked.
WARNING: ENGINE EXHAUST
To avoid injury from inhaling engine exhaust, always operate theengine in a well-ventilated area.Engine exhaust is toxic.
2 SPN 3251/FMI 16 - EPA10
4 All information subject to change without notice.Copyright ©2015 DETROIT DIESEL CORPORATION 3 09-15
9. Start the engine and run a Parked Regen. Monitor DOC inletpressure and engine speed during the regen. Compareyour DOC inletpressure reading to the screen shots and descriptions below in (aand b) to determine what step to go tonext.
a. If the DOC inlet pressure starts out high above 10 kPa (1.45psi) and decreases during the parked regen, thisindicates the DPFswere plugged and the parked regen cleared them. Go to step 10.
b. If the DOC inlet pressure starts above 6 kPa (0.8psi), andstays high, the DOC is considered plugged. Go to step11.
3 09-15
All information subject to change without notice. 5309-15 Copyright © 2015 DETROIT DIESEL CORPORATION
10. The parked regen has reduced the DOC inlet pressure byreducing the soot accumulated in the DPF. Verify the faultcode isgone and fill out the “ATD Checklist - EPA07/EPA10/GHG14”. Refer tosection "ATD Checklist - EPA07/EPA10/GHG14".
11. Using DiagnosticLink 8.0 SP1 or later, perform the DOC facecleaning routine. Refer to section "EPA10 and GHG14Diesel OxidationCatalyst Face Cleaning".
2 SPN 3251/FMI 16 - EPA10
6 All information subject to change without notice.Copyright ©2015 DETROIT DIESEL CORPORATION 3 09-15
1 3 09-152 SPN 3251/FMI 16 - EPA10
Recommended
Cummins QSX15 Tier 4 Fault Codes - alliedsystems.com· Cummins QSX15 Tier 4 Fault Codes Fault Code J1939 SPN J1939 FMI Lamp J1939 SPN Description Cummins Description QSB 6.7 QSL
Documents
1 01 16-17 - National Highway Traffic Safety Administration· 2018. 12. 16.· 2 SPN 4752/FMI 0 - GHG17 Exhaust Gas Recirculation Cooler Low Efficiency Table 1. SPN 4752/FMI 0 Description
Documents
TOURING - CH Bus Sales· 2014-11-21· 4|TS 45 Rev. 00 / 14.05.14 FAUT CODES EnginE (Cummins) SPN FMI TEMSA DTC J1939 SPN/FMI Description Cummins Fault Code Cummins Description
Documents
ACM Fault Codes | MDEG - Freightliner Trucksddcsn-ddc.freightliner.com/cps/rde/xbcr/ddcsn/DDC-SVC...ACM Fault Codes | MDEG – GHG17 Page | 7 SPN FMI ACM FAULT CODE DESCRIPTION MDEG
Documents
2020 FMI OVERVIEW - Home | FMI
Documents
SA 0 - RV TechMag - RV Tech Magazine 0 SAE Diagnostic Trouble Codes and Cummins Fault Codes SAE J1939 SPN SAE J1939 FMI Lamp Color MIL Lamp Status J1939 SPN/FMI Description Fault Code
Documents
QuickServe Online Service Training - Indiana Motor Truck ...· Fault Code Search Tab ... Enter all active fault codes and any inactive fault ... reference SPN/FMI Codes with Cummins
Documents
SPN 3251/FMI 0, 1, and 16 - Freightliner Trucks· 2014-04-23· SPN 3251/FMI 0, 1, and 16 SPN 3251/FMI 0, 1, and 16 Keywords: The diagnostics have been corrected and are all new.
Documents
4th CCI collocation Meeting...np_omi# ral np_iasi ulb lp_sciamachy ubr/fmi lp_omps# ubr/fmi lp_mipas kit/fmi lp_gomos esa/fmi lp_osiris uos/fmi lp_smr chalm/fmi lp_ace uoft/fmi lp_sageii
Documents
SPN 3055 FMI 15 Below Minimum with Maximum Command ...· SPN 157 FMI 3 (FRP), SPN157 FMI 4, SPN 157 FMI 20, and SPN 157 FMI 21 (FRP), and SPN 633 FMI 3, SPN 633FMI 4, and SPN 633
Documents
TOURING - CH Bus Sales · PDF file4|TS 45 Rev. 00 / 14.05.14 FAUT CODES EnginE (Cummins) SPN FMI TEMSA DTC J1939 SPN/FMI Description Cummins Fault Code Cummins Description 629 12
Documents
DTC-Codes for Bosch MD1 ECUs€¦· Deutz DTC-Codes for MD1 ECUs Diagnoses- and ErrorCodes DTC-Code SPN FMI Fehlerbescheibung Error Identification Revision date: 03.07.2020 Overview
Documents
TULC Combination Sensor - SSI Technologies, Inc· Concentration FMI J1939 PGN 64923 SPN 3520 (byte 5) Reagent Type J1939 PGN 64923 ... Maximum 102 OBD Sensor Failure Detected Output
Documents
Cummins Tier 4 Fault Codes - alliedsystems.com· 2020. 11. 10.· Rev: 11/10/2020 Page 1 of 30. Cummins Tier 4 Fault Codes Fault Code J1939 SPN J1939 FMI Lamp J1939 SPN Description
Documents
SPN 1590 FMI 9 -(CPC)(GHG14) and SPN 1590 … Enabling Conditions Key is on, CPC is online, CAN network is online, Adaptive Cruise Control System is equipped, 10 seconds after the
Documents
DTC-List-EMR4 Revision date: 14.07· 2018. 2. 23.· DTC-List-EMR4 Diagnoses- and ErrorCodes Code SPN FMI Blink codeFehlerbescheibung Error Identification Revision date: 14.07.2017
Documents
Fault Codes - CH Bus Sales· Transmission (Allison) ... SPN FMI TEMSA DTC J1939 SPN/FMI Description Cummins Fault Code Cummins Description 629 12 100 Controller #1 Bad Intelligent
Documents
TOURING - CH Bus Sales· EnginE (Cummins) SPN FMI TEMSA DTC J1939 SPN/FMI Description Cummins Fault Code Cummins Description. circuit. aBs - EsC (WaBCo) ...
Documents